Last time we talked about the nature of propane gas, and made a few points about taking care of propane storage cylinders. We’re back again to postulate on other propane peculiarities.
LP gas is a highly concentrated substance—there’s an awful lot of energy packed into that little container. Just how much? Glad you asked! From the technical side, there are roughly 91,000 BTUs (British thermal units) in a gallon of LP. So how does this work out? The typical RV refrigerator burner runs off about 5,000 per hour. That would mean over 18 hours of full-blown operating time on a gallon—but of course, unless you’re in a really hot climate, your fridge will be switching off and on.
Big consumers of propane are water heaters and furnaces. A 25,000 BTU (measured at input) furnace will run off five gallons of LP in that same 18-hour period.. Long showers are costly: A six-gallon RV water heater eats up 12,000 BTUs of running time. Here are some hints on cutting down the use of LP:
In warmer weather, switch your water heater valve to “pilot” (assuming you don't have electronic ignition) and let the pilot light keep the water warm. Some report that with judicious use of showers they can actually keep from lighting off that main burner and let the pilot do it all.
When shopping for a new furnace, compare the input BTU figures to the output—if 85 percent or more of your heat is going into your RV, that’s pretty good efficiency. But to make your LP go almost 100 percent, consider using a “blue flame” or catalytic style heater—almost 100 percent efficiency, and no use of 12-volt power to run a blower fan.
Out on the road you may find not everything sold as propane is the same. In a few areas, particularly in parts of Mexico, the product sold as propane has a higher proportion of butane gas than that sold in most areas of the U.S. That’s not usually a problem, as higher butane content LP burns just as well as that made up with lesser concentrations of butane. A problem can creep up if you take the “more butane in the mix” LP to colder climates. Where the ambient air temperature is below freezing, butane will not vaporize correctly, which can leave you with an inoperative gas system. If you gas up in Mexico, you’re best off using up the load before you head to the colder areas of the states.
Drive with the valves open or closed? We’ve never seen a definitive study, but some tell us they do. Others forswear having the refrigerator cold while motoring, telling us they feel a lot safer with the LP turned off. We used to be of the latter camp: If we were out of camp, the valves were closed. Then we started motoring through the desert country in summertime and found that here was an exception to our old maxim: “Keep the reefer door shut, it’ll stay cold enough.”
Yes, it’s nice having the food cold, and not fearing a case of food poisoning. At the same time, there is that bit of dread. The old “what ifs” keep flowing: What if we forget to shut off that refrigerator when we pull into a gas station, and the worst thing happens? What if we get pushed off the road by a big truck and we tip the unit over, and an LP line breaks? A disaster is the answer to both of those “what ifs.” Wherever possible, we prefer to run with our appliances turned off, and the gas valves closed.
If you decide to run with your valves open, then ALWAYS stop before you get into a refueling station of any kind (gas or LP) and TURN OFF any gas fired appliances. Standing pilots or automatic ignition, either way, the pilot or the spark from ignition can really create an explosion hazard under the right circumstances.
It's wise to do an annual LP system safety check. Using soapy water solution (heavy on the dish soap) or an LP gas sniffer, check all gas connections inside and outside your rig. If you have (and know how to use) a manometer (gas pressure gauge), then check to make sure your LP gas regulator is doing its job correctly. Don’t have one? Call around and find out what RV service facility will give you a good rate to test your regulator, and give you some peace of mind.
Check out all gas-using appliances for insect encroachment. Some wasps think the odor of LP is like honey to their cousins. They’ll build little nests in RV vents, causing appliance malfunctions, or worse, allowing for a buildup of deadly carbon monoxide gas inside your rig.
LP gas is a wonderful tool for RVers. Use it with care, observe appropriate safety cautions, and you’ll have plenty of good times in your RV.
LP gas is a highly concentrated substance—there’s an awful lot of energy packed into that little container. Just how much? Glad you asked! From the technical side, there are roughly 91,000 BTUs (British thermal units) in a gallon of LP. So how does this work out? The typical RV refrigerator burner runs off about 5,000 per hour. That would mean over 18 hours of full-blown operating time on a gallon—but of course, unless you’re in a really hot climate, your fridge will be switching off and on.
Big consumers of propane are water heaters and furnaces. A 25,000 BTU (measured at input) furnace will run off five gallons of LP in that same 18-hour period.. Long showers are costly: A six-gallon RV water heater eats up 12,000 BTUs of running time. Here are some hints on cutting down the use of LP:
In warmer weather, switch your water heater valve to “pilot” (assuming you don't have electronic ignition) and let the pilot light keep the water warm. Some report that with judicious use of showers they can actually keep from lighting off that main burner and let the pilot do it all.
When shopping for a new furnace, compare the input BTU figures to the output—if 85 percent or more of your heat is going into your RV, that’s pretty good efficiency. But to make your LP go almost 100 percent, consider using a “blue flame” or catalytic style heater—almost 100 percent efficiency, and no use of 12-volt power to run a blower fan.
Out on the road you may find not everything sold as propane is the same. In a few areas, particularly in parts of Mexico, the product sold as propane has a higher proportion of butane gas than that sold in most areas of the U.S. That’s not usually a problem, as higher butane content LP burns just as well as that made up with lesser concentrations of butane. A problem can creep up if you take the “more butane in the mix” LP to colder climates. Where the ambient air temperature is below freezing, butane will not vaporize correctly, which can leave you with an inoperative gas system. If you gas up in Mexico, you’re best off using up the load before you head to the colder areas of the states.
| Image may be NSFW. Clik here to view.  |
| R and T De Maris |
Yes, it’s nice having the food cold, and not fearing a case of food poisoning. At the same time, there is that bit of dread. The old “what ifs” keep flowing: What if we forget to shut off that refrigerator when we pull into a gas station, and the worst thing happens? What if we get pushed off the road by a big truck and we tip the unit over, and an LP line breaks? A disaster is the answer to both of those “what ifs.” Wherever possible, we prefer to run with our appliances turned off, and the gas valves closed.
If you decide to run with your valves open, then ALWAYS stop before you get into a refueling station of any kind (gas or LP) and TURN OFF any gas fired appliances. Standing pilots or automatic ignition, either way, the pilot or the spark from ignition can really create an explosion hazard under the right circumstances.
It's wise to do an annual LP system safety check. Using soapy water solution (heavy on the dish soap) or an LP gas sniffer, check all gas connections inside and outside your rig. If you have (and know how to use) a manometer (gas pressure gauge), then check to make sure your LP gas regulator is doing its job correctly. Don’t have one? Call around and find out what RV service facility will give you a good rate to test your regulator, and give you some peace of mind.
Check out all gas-using appliances for insect encroachment. Some wasps think the odor of LP is like honey to their cousins. They’ll build little nests in RV vents, causing appliance malfunctions, or worse, allowing for a buildup of deadly carbon monoxide gas inside your rig.
LP gas is a wonderful tool for RVers. Use it with care, observe appropriate safety cautions, and you’ll have plenty of good times in your RV.